Nihal Farid younes

Keratomycosis is a serious corneal disease that can cause a permanent visual disability if not treated effectively. Sertaconazole nitrate (STZ), a novel broad spectrum antifungal drug, was suggested as a promising treatment. However, its utility in the ocular route is restricted by its poor solubility, along with other problems facing the ocular delivery like short residence time, and the existing corneal barrier. Therefore, the objective of this study was to formulate STZ loaded binary mixed micelles (STZ-MMs) enriched with different penetration enhancers using thin-film hydration method, based on a 3.2 mixed factorial design. Different formulation variables were examined, namely, type of auxiliary surfactant, type of penetration enhancer, and total surfactants: drug ratio, and their effects on the solubility of STZ in MMs (S), particle size (PS), polydispersity index (PDI), and zeta potential (ZP) were evaluated. STZ-MMs enhanced STZ aqueous solubility up to 338.82-fold compared to free STZ. Two optimized formulations (MM-8 and MM-11) based on the desirability factor (0.891 and 0.866) were selected by Design expert software for further investigations. The optimized formulations were imaged by TEM which revealed nanosized spherical micelles. Moreover, they were examined for corneal mucoadhesion, stability upon dilution, storage effect, and ex vivo corneal permeation studies. Finally, both in vivo corneal uptake and in vivo corneal tolerance were investigated. MM-8 showed superiority in the ex vivo and in vivo permeation studies when compared to the STZ-suspension. The obtained results suggest that the aforementioned STZ loaded mixed micellar system could be an effective candidate for Keratomycosis-targeted therapy.

Amisulpride (AMS) is atypical antipsychotic with a weak basic nature (pKa 9.37), which results in low solubility in the high pH of the intestine. It is also recognized as a substrate of P-glycoprotein efflux pump. Both factors lead to its low oral bioavailability (48%). The daily dose of AMS is between 200 and 1200 mg to be taken in divided doses which compromise patient compliance. Therefore, controlled release formulation of AMS is of clinical significance. AMS was formulated into matrix tablets containing Labrasol, P-glycoprotein efflux inhibitor, and a penetration enhancer, using direct compression technique. The tablets were prepared according to 2·4 factorial design using two polymers, namely, HPMC and Carbopol 934 at four concentrations (20%, 30%, 40%, 50%). Percentage AMS released after 2 h (Q%) and 8 h (Q%) were chosen as dependent variables. Two acidic pH modifiers (fumaric acid and tartaric acid) at two levels (15% and 30%) were incorporated in the tablet according to 2 factorial design. All formulae with acidic pH modifier had similarity factor (f) ≥ 50 proving the pH independent release of AMS. The pharmacokinetic study in rabbits revealed 30% enhancement of the oral absorption AMS imparted by the pH-modified matrix tablet containing Labrasol. Graphical abstract.

Amisulpride (AMS), a second generation antipsychotic, suffers from low oral bioavailability (48%). This might be due to its pH-dependent solubility or being a substrate of P-glycoprotein efflux pump. Nanostructured lipid carriers (NLCs) were proposed in this study to enhance the oral absorption of AMS. AMS-NLCs were prepared by solvent evaporation technique according to (2.4.3) factorial design, whereas the type of solid lipid (tripalmitin or Gelucire® 43/1), lipid to drug ratio (7:1, 10:1, or 13:1) and type of external suspending medium (double distilled water, 0.5% TSP pH 12, 1% HPMC or 2.5% glycerin) were the independent variables. The average entrapment efficiency, particle size, polydispersity index, and zeta potential of the prepared formulations ranged from 29.01 to 69.06%, 184.9 to 708.75 nm, 0.21 to 0.59, and - 21 to - 33.55 mV, respectively. AMS-NLCs were optimized according to the desirability function to maximize the entrapment efficiency and minimize the particle size. Formulae G12, G10, and G7 with the highest desirability values of 0.915, 0.84, and 0.768, respectively, were chosen for further investigations. Novel AMS-NLCs capsules were prepared from the lyophilized formulations (TG7 and MG10) to enhance stability and increase patient compliance. The capsules were evaluated in terms of weight variation, content uniformity, and in vitro release pattern. The pharmacokinetics of AMS-NLCs capsules (formula TG7) were tested in rabbits compared to the commercial Amipride® tablets. The relative bioavailability of AMS-NLCs capsules was found to be 252.78%. In conclusion, the NLC-based capsules show potential to improve the oral bioavailability of AMS.

Sertaconazole nitrate (STZ) is a poorly soluble antifungal drug commonly used for treating fungal skin infections. Introducing it as a new treatment option for the management of fungal keratitis, requires the development of a delivery system capable of targeting the infected cornea with an adequate STZ concentration. Hence, Sertaconazole nitrate loaded cubosomes (STZ-CUBs) were prepared, characterized and optimized based on a 3 central composite face-centred design. Optimized formulation (CUB-opt) showed maximum desirability (0.905), with solubilization efficiency (SE%) of 94.50 ± 0.51%, particle size (PS) of 216.55 ± 2.33 nm, polydispersity index (PDI) of 0.229 ± 0.11 and zeta potential (ZP) of 34.00 ± 6.93 mV. Under the transmission electron microscope, it showed discrete cubic shaped structures. Moreover, it exhibited a promising mucoadhesive behavior, terminal sterilization stability, and storage stability. Ex vivo corneal permeation study revealed its ability to enhance the steady state flux (J) and the permeability coefficient (K) of STZ, compared to STZ-suspension. Finally, CUB-opt formulation was found to be safe on the corneal tissues in the in vivo corneal tolerance study, and demonstrated a superior corneal penetration power in the in vivo corneal uptake study.